Giáo trình công nghệ chi tiết sử dụng ắc QUY viễn thông dạng gel CG2 600
Bạn đang xem bản rút gọn của tài liệu. Xem và tải ngay bản đầy đủ của tài liệu tại đây (365.31 KB, 2 trang )
CG2-600
2V 600Ah(10hr)
Gel battery shows some distinctive advantages over flooded battery or AGM battery,
such as super thermal stability, high deep discharge capability, good recovery from
deep discharge , even if the battery is left discharged for three days, it will recover
to 100% of capacity. With the above-mentioned advantages, the gel battery has
long service life, specially suitable for motive power applications, such as golf trailer,
sruubber, folklift,etc.The deep discharge cycles increased 50% as compared with
the AGM battery.
Battery Construction
Component
Positive plate
Negative plate
Container
Cover
Safety valve
Terminal
Raw material
Lead dioxide
Lead
ABS
ABS
Rubber
Copper
General Features
● Nanometer SiO 2 and H 2 SO 4 gelled
electrolyte technology for efficiency
gas recombination of up to 99% and
freedom from electrolyte maintenance
or water adding.
● Not restricted for air transport-complies
with IATA/ICAO Special Provision A67.
● UL-recognized component.
● Can be mounted in any orientation.
● Computer designed lead, calcium tin alloy
grid for high power density.
● Long service life, float or cyclic
applications.
● Maintenance-free operation.
● Low self discharge.
● Case and cover avaiable in both standard
and flame restardant ABS.
Dimensions and Weight
Length(mm / inch)
Width(mm / inch)
Height(mm / inch)
Total Height(mm / inch)
Approx. Weight(Kg / lbs)
302 / 11.9
175 / 6.89
330 / 13.0
367 / 14.5
40 / 88.2
* Weight deviation: ± 3%
Separator
PVC
Electrolyte
Gelled acid
Performance Characteristics
Nominal Voltage
2V
Number of cell
1
Design Life
20 years
Nominal Capacity 77oF(25oC)
10 hour rate (60.0A, 1.80V)
600Ah
5 hour rate (106A, 1.75V)
530Ah
1 hour rate (372A, 1.60V)
372Ah
Internal Resistance
Fully Charged battery 77oF(25oC)
≤ 0.7mOhms
Self-Discharge
2% of capacity declined per month at 20oC(average)
Operating Temperature Range
Discharge
-20~60oC
Charge
-10~60oC
Storage
-20~60oC
2200A(5s)
Max. Discharge Current 77oF(25oC)
Charge Methods: Constant Voltage Charge 77oF(25oC)
2.40-2.45VPC
Cycle use Charge Voltage:
Maximum charging current
120A
-5mV/ oC
Temperature compensation
2.20-2.30VPC
Standby use
-3.3mV/ oC
Temperature compensation
Discharge Constant Current (Amperes at 77oF25oC)
End point
volts/cell
1.60V
1.65V
1.70V
1.75V
1.80V
10min 15min 30min
1260
1188
1116
1044
972
1032
960
912
840
768
600
588
576
564
540
1h
3h
5h
10h
20h
372
360
348
336
318
156
152
148
146
140
114
110
108
106
102
63.0
62.4
61.2
60.6
60.0
33.6
33.0
32.4
32.1
31.5
Discharge Constant Power (Watts at 77oF25oC)
End point
volts/cell
1.60V
1.65V
1.70V
1.75V
1.80V
Total height with removeable cover: 367
10min 15min 30min
2157
2053
2000
1904
1804
1750
1736
1663
1559
1475
1123
1073
1023
993
950
1h
3h
5h
10h
20h
696
662
635
613
585
292
277
263
250
235
219
207
197
193
180
122
111
109
105
97.9
66.1
62.3
59.6
57.5
55.4
(Note)The above characteristics data are average values obtained within
three charge/discharge cycles not the mimimum values.
All data shall be changed without notice,Vision reserves the right to explain
and update the information contained hereinto.
page1 of 2
www.vision-batt.com
CG2-600
O
Charging characteristic for Cycle use
2.40
100
0.14
2.20
600A 372A
80
60
40
1.60
0.05
1.40
0
8
12
16
20
24
Self-discharge characteristic
110
(V/CELL)
100
Capacity(%)
(V/6V)
(V/4V)
4
Charging time (hours)
Relationship between
charging voltage and temperature
(V/8V)
100%(0.1CAx10H)
---- 50%(0.1CAx5H)
Charge
Charge Voltage(2.45V/Cell)
Charge Current 0.1CA
o
Temperature25 C
1.80
0.08
Discharge time
(V/12V)
Discharge
2.00
0.11
0.02
20
)Ratio
Voltage(V)/PerCell
0.17
ChargeCurrent(CA)
146A 106A 60A
1260A
120
Charged Volume(%)
Battery voltage(V)
Discharge characteristic (25 C)
2V 600Ah
90
15.6
10.4
7.8
5.2
2.6
15.0
10.0
7.5
5.0
2.5
14.4
9.6
7.2
4.8
2.4
13.8
9.2
6.9
4.6
2.3
60
13.2
8.8
6.6
4.4
2.2
50
-10
0
10
20
30
40
50
80
70
40
60
Ambient temperature( oC)
0
3
6
9
12
15
18
21
Storage time: months
24
27
30
Cycle service life in relation to
depth of discharge
Capacity(%)
Life characteristics of Standby use
50% Depth of discharge
Number of cycles(cycles)
Life(year)
Temperature effects on capacity
Capacity (%)
Life(years)
Temperature effects on float life
Temperature( oC)
THE INTERNATIONAL CERTIFICATION NETWORK
ISO9001:2008
MH25860
G4M19906-9202-E-16
www.vision-batt.com
Shenzhen Center Power Tech. Co., Ltd.
Center Power Industrial Park, Tongfu Industrial District Dapeng Town, 518120 Shenzhen, China
Tel: (+86-755) 8431 8088 Fax: (+86-755) 8431 8038 E-mail:
Copy Right Shenzhen Center Power Technology Co., Ltd (Edition 2014-1)
Page 2 of 2
